Vollrath CC404A-Water Cooled Manuel d'utilisateur

Model CC101, CC202, CC303, CC404OWNERS MANUALManual No. 513642 Rev.2

Owner’s Manual #513642 4 CC Model MachinesFigure 1-4 Model CC202 DimensionsFigure 1-5 Model CC404 Dimensions

Owner’s Manual #513642 5 CC Model Machines1.3 INTERNATIONAL ELECTRICAL SPECIFICATIONSThe table below shows the electrical requirements per barrel.

Owner’s Manual #513642 6 CC Model Machines

Owner’s Manual #513642 7 CC Model MachinesSECTION 2INSTALLATION INSTRUCTIONS2.1 SAFETY PRECAUTIONSDo not attempt to operate the machine until the sa

Owner’s Manual #513642 8 CC Model Machines3 Insulate the suction line with a minimum of 3/8” wall thickness or the wall thickness required by local

Owner’s Manual #513642 9 CC Model MachinesD. RECEIVING AND INSTALLING REMOTE CONDENSING UNITSNOTEThe remote condensing units may be sent prior to de

Owner’s Manual #513642 10 CC Model Machines4 Connect the refrigeration lines from the line sets to the machine. Access the machine from the left or

Owner’s Manual #513642 11 CC Model Machines2 Disassemble, clean and sanitize each freezing cylinder. Refer to the Section 3 for proper instructions

Owner’s Manual #513642 12 CC Model Machines

Owner’s Manual #513642 13 CC Model MachinesSECTION 3INITIAL SET-UP AND OPERATION3.1 OPERATOR’S SAFETY PRECAUTIONS SAFE OPERATION IS NO ACCIDENT; obs

Owner’s Manual #513642 14 CC Model MachinesB. Freezing Cylinder Off/On The Freezing Cylinder OFF/ON switch is a two position toggle switch used to

Owner’s Manual #513642 15 CC Model MachinesJ. Front Door Safety Switch The front door safety switch prevents the auger from turning when the front

Owner’s Manual #513642 16 CC Model MachinesNOTEThe Product Selector switch can be changed until the READY message is displayed on the second line.G.

Owner’s Manual #513642 17 CC Model MachinesA. Prepare detergent water by mixing 2 oz. of Palmolive detergent or equivalent in 2 gallons of 90° to 1

Owner’s Manual #513642 18 CC Model MachinesE. Lubricate the inside and outside of the front wear bushing with Petrol Gel and install it onto the au

Owner’s Manual #513642 19 CC Model MachinesE. CLEANING AND SANITIZING INFORMATIONSpecial consideration is required when it comes to food safety and

Owner’s Manual #513642 20 CC Model Machines2. MACHINE DAMAGE – Strong acids will attack metal and rubber causing premature wear of parts. The use o

Owner’s Manual #513642 21 CC Model MachinesSECTION 4TROUBLESHOOTING4.1 ERROR CODESWhen the machine experiences a problem, one of the following error

Owner’s Manual #513642 22 CC Model MachinesError Code 6 - Hopper Sensor The Hopper Sensor Error (E6) will not occur on a CC model machine.Error Cod

Owner’s Manual #513642 23 CC Model Machines4.3 TROUBLESHOOTING TABLESPROBLEM POSSIBLE CAUSE REMEDYCustard is running too cold or auger blades chatte

This manual provides basic information about the machine. Instructions and suggestions are given covering its operation and care.The illustrations and

Owner’s Manual #513642 24 CC Model Machines

Owner’s Manual #513642 25 CC Model MachinesSECTION 5REPLACEMENT PARTS Part Description Quantity BR-0020 Brush - Tubing (1/2”) 1 BR-0030 Brush

Owner’s Manual #513642 26 CC Model Machines5.2 AUGER SHAFT AND FACEPLATE PARTS Part Description Quantity C-2000-50 Spring 12 per barrel C-2000

Owner’s Manual #513642 27 CC Model Machines Part Description Quantity 754017 Tube - Flow Control (Hopper) 1 per barrel 2187750 Tray - Drain (

Owner’s Manual #513642 28 CC Model Machines

September 1, 2007 Form 721-053, Rev.01 Page 1 of 1 ROSS & TELME WARRANTY 1. Scope: Stoelting, LLC warrants to the first user (t

Safety Alert Symbol:This symbol Indicates danger, warning or caution. Attention is required in order to avoid serious per-sonal injury. The message th

Section Description Page 1 Description and Specifi cations 1.1 Description ...

Owner’s Manual #513642 1 CC Model Machines1.1 DESCRIPTIONThe CC series machines are continuous fl ow custard ma-chines. They are equipped with fully

Owner’s Manual #513642 2 CC Model Machines1.2 SPECIFICATIONSCC202A Air Cooled Remote CC202A Water CooledDimensionsMachine with crate Machine with cr

Owner’s Manual #513642 3 CC Model MachinesCC404ADimensions Machine with cratewidth 42-1/2’’ (108,0 cm) 50’’ (127,0 cm)height 61-7/8’’ (157,2 cm) 67’